隨著社會經濟的發展，防火卷簾門的應用已經很是普遍了，很多人對于防火卷簾門的維修也是很關注，下面濟南防火卷簾門安裝維修廠家為大家介紹防火卷簾門的維修標準。

With the development of social economy, the application of fire rolling shutter doors has become very common, and many people are also concerned about the maintenance of fire rolling shutter doors. Now, the Jinan fire rolling shutter door installation and maintenance manufacturer will introduce the maintenance standards of fire rolling shutter doors.

1．適用范圍：大廈內防火分區、地下停車場用防火卷簾門的保養。

1. Scope of application: maintenance of fire compartment and fire rolling shutter doors for underground parking lot in the building.

2．引用標準：無。

2. Reference standards: None.

3．日常保養：

3. Daily maintenance:

周期：月

Period: month

外觀檢查門軌、門扇有無變形、卡阻現象；操作按鈕箱是否良好上鎖。

Visually check the door rail and door leaf for deformation and jamming; Whether the operation button box is locked properly.

檢查防火卷簾門電控箱指示燈是否正常，箱體有否受損。

Check whether the indicator of the electric cabinet of the fire shutter door is normal and whether the cabinet is damaged.

開啟按鈕，按下上（或下）按鈕，卷簾門應上升（或下降）如果卷簾門升降與按鈕操作上下不一樣，要立即停車，修復后方可重新操作。

Open the button, press the up (or down) button, and the rolling shutter door shall rise (or fall). If the lifting of the rolling shutter door is different from the up and down operation of the button, stop the vehicle immediately, and operate it again after repair.

在按鈕操作上升（或下降）過程中，操作人員嚴禁離開現場，操作的同時，要密切注意簾門上升（或下降）到一定位置之后地否能自動停車。如果簾門上升到位后（或下降已到地面）仍不停，一定要待限位裝置修復（或調整）正常后方可重新操作。

In the process of button operation rising (or falling), the operator is strictly prohibited from leaving the site. While operating, pay close attention to whether the curtain door can automatically stop after rising (or falling) to a certain position. If the curtain door still does not stop after it is lifted to the right position (or lowered to the ground), it must not be operated again until the limit device is repaired (or adjusted) normally.

二次下滑關閉后，待探測器信號后方可重新開啟簾門。

After the second sliding closing, the curtain door can be reopened after the detector signal is eliminated.

做好保潔工作，清掃電機、控制箱等外表灰塵。

Clean the motor, control box and other surfaces.

在以上保養中出現異常問題時，應在當天予以糾正，保證系統正常。

If abnormal problems occur during the above maintenance, they should be corrected on the same day to ensure the system is normal.

4．一級保養

4. First level maintenance

周期：季

Period: quarter

完成月保養的內容

Complete the monthly maintenance

雙探測器（門兩側分裝）或單探測器（門一側安裝）任一煙感或溫感動作時，將自動啟動裝置，裝置發出報警聲，同時自動啟動簾門電控系統，如防火卷簾門做防火分區用，則一次下滑到底；如防火卷簾門兼做逃生口用，則兩次下滑關閉防火卷簾門（防火卷簾門一次下滑離地面1.8米左右停止，延時三十秒左右，二次再自動下行關閉）。

In case of any smoke or temperature sensing action of double detectors (separately installed on both sides of the door) or single detectors (installed on one side of the door), the device will automatically start, the device will give an alarm sound, and the electric control system of the shutter will automatically start. If the fire shutter door is used as a fire compartment, it will slide down to the bottom at one time; If the fire rolling shutter door is also used as an escape exit, the fire rolling shutter door will be closed by sliding down twice (the fire rolling shutter door will stop when it slides down to about 1.8 meters above the ground once, delaying about 30 seconds, and it will be closed automatically when it slides down again twice).

消防中心遙控檢查。

Remote control inspection of fire control center.

操作按鈕下滑關閉簾門，關閉到位將有信號反饋到消防中心顯示。緊固各部分鏍釘及聯軸。

The operation button slides down to close the curtain door. When it is closed in place, a signal will be fed back to the fire center for display. Fasten all screws and couplings.

絕緣電阻應符合規定。

The insulation resistance shall meet the requirements.

5．二級保養：

5. Secondary maintenance:

周期：年

Period: years

完成一級保養的內容。

Complete the first level maintenance.

整體檢查，對局部變形及油漆脫落現象進行修復。

Conduct overall inspection and repair local deformation and paint peeling.

逐一檢查控制箱內各按鈕及元件是否正常。

Check whether the buttons and elements in the control box are normal one by one.

調整電機傳動皮帶的松緊度。

Adjust the tightness of the motor drive belt.

向防火卷簾門的轉動部位填加潤滑油，以保證聯軸器及軸承的靈活性及穩定性。

Add lubricating oil to the rotating part of the fire shutter door to ensure the flexibility and stability of the coupling and bearing.

對檢查發現的缺陷逐一修復。

Repair the defects found in the inspection one by one.

相關文件及記錄，消防設備保養表。

Relevant documents and records, fire equipment maintenance sheet.

防火卷簾門的維修標準大致就是如此了，這可以算是一個章程，大家可以根據上述的內容進行防火卷簾門的維修，值得注意的是，大家一定要進行定期的檢查，千萬不要疏忽了。更多相關內容來我們網站http://luoboyy.com咨詢吧！

The maintenance standard of the fireproof rolling shutter door is roughly like this, which can be regarded as a regulation. You can carry out the maintenance of the fireproof rolling shutter door according to the above contents. It is worth noting that you must carry out regular inspection and never neglect it. Come to our website for more information http://luoboyy.com Consult!